HomeMy WebLinkAboutDiversey JWorks TempestJ-Works Tempest 64 Solvent-Free Cleaner/Detergent
SAFETY DATA SHEET
Version Number: 1 Preparation date: 2014-05-01
1. IDENTIFICATION
Product name:J-Works Tempest 64 Solvent-Free Cleaner/Detergent
Product Code:95002232, 95006516, 95271352, 96272110, 96272550, 95711928
SDS #:MS0800112
Recommended use:• Cleaner/Degreaser
• This product is intended to be diluted prior to use
Uses advised against:Uses other than those identified are not recommended
Emergency telephone number:1-800-851-7145 (U.S.); 1-651-917-6133 (Int'l)
2. HAZARDS IDENTIFICATION
Classification for the undiluted product
Skin corrosion/irritation Category 2
Serious eye damage/eye irritation Category 1
Signal Word: Danger.
Precautionary Statements
CAUSES SKIN IRRITATION. CAUSES SERIOUS EYE DAMAGE.Avoid contact with eyes, skin and clothing. Causes burns/ serious damage to mouth, throat and stomach. Keep container tightly closed. Washaffected areas thoroughly after handling. Wear chemical-splash goggles and chemical-resistant gloves. IF SWALLOWED: Rinse mouth. DO NOT
induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or water. IF ON SKIN: Wash with plenty of soap and water. If
skin irritation occurs: Get medical advice or attention. IF INHALED: Remove person to fresh air and keep comfortable for breathing. IF IN EYES:
Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least 15 minutes.
Immediately call a Poison Center (1-800-851-7145) or physician. Take off contaminated clothing and wash it before reuse. Dispose of inaccordance with all federal, state and local applicable regulations. SUPPLEMENTAL INFORMATION: Mix only with water. DO NOT MIX WITH ANY
OTHER PRODUCT OR CHEMICAL. Can react to release hazardous gases.
Health hazards not otherwise classified (HHNOC) - Not applicable
Physical hazards not otherwise classified (PHNOC) - Not applicable
J-Works Tempest 64 Solvent-Free
Cleaner/Detergent
Manufacturer, importer, supplier:
US Headquarters
Sealed Air
8215 Forest Point Blvd.
Charlotte, NC 28273-5509
Phone: 1-888-352-2249
SDS Internet Address: www.sds.sealedair.com
1 of 5
Canadian Headquarters
Sealed Air - Canada
3755 Laird RoadMississauga, Ontario L5L 0B3
Phone: 1-800-668-3131
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s)CAS #Weight %
Sodium silicate 1344-09-8 3% - < 5%
Sodium xylene sulfonate 1300-72-7 3% - < 5%
Alcohol ethoxylates 68439-46-3 3% - < 5%
Tetrasodium salt of EDTA 64-02-8 1% - < 3%
Sodium hydroxide 1310-73-2 1% - < 3%
*Exact percentages are being withheld as trade secret information
4. FIRST AID MEASURES
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: IF ON SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical advice/attention.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
Most Important Symptoms/Effects: No information available.
Immediate medical attention and special treatment needed Not applicable.
Aggravated Medical Conditions: Persons with pre-existing skin disorders may be more susceptible to irritating effects.
5. FIRE-FIGHTING MEASURES
Specific methods:No special methods required
Suitable extinguishing media:The product is not flammable. Extinguish fire using agent suitable for surrounding fire.
Specific hazards:Not applicable.
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
6. ACCIDENTAL RELEASE MEASURES
Personal precautions:Put on appropriate personal protective equipment (see Section 8.).
Environmental precautions
and clean-up methods:
Clean-up methods - large spillage. Absorb spill with inert material (e.g. dry sand or earth), then place in
a chemical waste container. Use a water rinse for final clean-up.
7. HANDLING AND STORAGE
Handling: Avoid contact with skin, eyes and clothing. Do not taste or swallow. Remove and wash contaminated clothing and footwear before
Classification for the diluted product @ 1:5
This product, when diluted as stated on the label, is not classified as hazardous according to OSHA 29CFR 1910.1200 (HazCom 2012-GHS) and
Canadian Hazardous Products Regulations (HPR) (WHMIS 2015-GHS).
Precautionary Statements
None required.
Diluted Product:
J-Works Tempest 64 Solvent-Free Cleaner/Detergent 2 of 5
Eyes: Rinse with plenty of water If irritation occurs and persists, get medical attention.
Skin: Rinse with plenty of water If irritation occurs and persists, get medical attention.
Inhalation: No specific first aid measures are required
Ingestion: Rinse mouth with water.
re-use. Wash thoroughly after handling. Product residue may remain on/in empty containers. All precautions for handling the product must be used
in handling the empty container and residue. Mix only with water. Do not mix with any other product or chemical. May react to release hazardous
gases. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Protect from freezing. Keep tightly closed in a dry, cool and well-ventilated place. KEEP OUT OF REACH OF CHILDREN.
Aerosol Level (if applicable) : Not applicable
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Exposure Guidelines:.
Ingredient(s)CAS #ACGIH OSHA
Sodium silicate 1344-09-8 --
Sodium xylene sulfonate 1300-72-7 --
Alcohol ethoxylates 68439-46-3 --
Tetrasodium salt of EDTA 64-02-8 --
Sodium hydroxide 1310-73-2 2 mg/m3 (Ceiling)2 mg/m3 (TWA)
Undiluted Product:
Engineering measures to reduce exposure:
No special ventilation requirements General room ventilation is adequate
Personal Protective Equipment Eye protection:Chemical-splash goggles.
Hand protection:Chemical-resistant gloves.
Skin and body protection:No special protective clothing is required.
Respiratory protection:No special protective clothing is required.
Hygiene measures:Handle in accordance with good industrial hygiene and safety practice.
9. PHYSICAL AND CHEMICAL PROPERTIES:
Explosion limits: - upper: Not determined - lower: Not determined
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
10. STABILITY AND REACTIVITY
Reactivity:Not Applicable
Stability:The product is stable
Hazardous decomposition products:None reasonably foreseeable.
Materials to avoid:Do not mix with any other product or chemical.
Conditions to avoid:No information available.
11. TOXICOLOGICAL INFORMATION
Diluted Product:
Personal Protective Equipment
Eye protection:No personal protective equipment required under normal use conditions.
Hand protection:No personal protective equipment required under normal use conditions.
Skin and body protection:No personal protective equipment required under normal use conditions.
Respiratory protection:No personal protective equipment required under normal use conditions.
Hygiene measures:Handle in accordance with good industrial hygiene and safety practice.
Physical State: Liquid Color: Clear, Green
Evaporation Rate: No information available Odor: Surfactant
Odor threshold: No information available.Boiling point/range: Not determined
Melting point/range: Not determined Decomposition temperature: Not determined
Autoignition temperature: No information available Solubility: Completely Soluble
Solubility in other solvents: No information available Relative Density (relative to water): 1.0711
Density: 8.93 lbs/gal 1.0711 Kg/L Vapor density: No information available
Bulk density: No information available Vapor pressure: No information available.
Flash point: > 200 °F > 93.3 °C Partition coefficient (n-octanol/water): No information available
Dilution Flash Point: > 200 °F > 93.3 °C Viscosity: No information available
Elemental Phosphorus: 0.00 % by wt.VOC: 0 % *
pH: 12.85 VOC % by wt. at use dilution 0 % *
J-Works Tempest 64 Solvent-Free Cleaner/Detergent 3 of 5
Dilution pH: 12.42 @ 1:5 Flammability (Solid or Gas): Not applicable
Metal Corrosion: Not determined
Information on likely routes of exposure:
Eye contact, Skin contact, Inhalation, Ingestion
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Causes skin irritation. Symptoms may include pain (which may be delayed), redness, and/or discomfort.
Eye contact: Corrosive. Causes serious eye damage. Symptoms may include pain, burning sensation, redness, watering, blurred
vision or loss of vision.
Ingestion: Causes burns/ serious damage to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract. Symptoms may include coughing and
difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Numerical measures of toxicity
ATE - Oral (mg/kg):>5000
ATE - Inhalatory, mists (mg/l):>20
12. ECOLOGICAL INFORMATION
Ecotoxicity: No information available.
Persistence and Degradability: No information available.
Bioaccumulation: No information available.
13. DISPOSAL CONSIDERATIONS
Waste from residues / unused products: This product, as sold, if discarded or disposed, is a hazardous waste according to Federal regulations
(40 CFR 261.4 (b)(4)). Dispose in compliance with all Federal, state, provincial, and local laws and regulations. This product, when diluted as
stated on this SDS, is not a hazardous waste according to Federal regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the
user of the product to determine, at the time of disposal, whether the waste solution meets RCRA criteria for hazardous waste. Dispose in
compliance with all Federal, state, provincial, and local laws and regulations.
Contaminated Packaging: Do not re-use empty containers.
RCRA Hazard Class (undiluted product): D002 Corrosive Waste
RCRA Hazard Class (diluted product):Not Regulated
14. TRANSPORT INFORMATION
DOT/TDG/IMDG: Proper shipping descriptions can vary by pack size. Please refer to the Diversey HazMat Library, only available through
Internet Explorer, http://naextranet.diversey.com/dot/, for up to date shipping information.
DOT (Ground) Bill of Lading Description: CLEANING, WASHING, BUFFING, OR POLISHING COMPOUNDS LIQUID
IMDG (Ocean) Bill of Lading Description: CLEANING, WASHING, BUFFING, OR POLISHING COMPOUNDS LIQUID
15. REGULATORY INFORMATION
International Inventories at CAS# Level
All components of this product are listed on the following inventories: U.S.A. (TSCA), Canada (DSL/NDSL).
U.S. Regulations
J-Works Tempest 64 Solvent-Free Cleaner/Detergent 4 of 5
California Proposition 65: This product is not subject to the reporting requirements under California's Proposition 65.
RIGHT TO KNOW (RTK)
Ingredient(s)CAS #MARTK:NJRTK:PARTK:RIRTK:
Water 7732-18-5 ----
Sodium silicate 1344-09-8 ----
Sodium xylene sulfonate 1300-72-7 ----
Alcohol ethoxylates 68439-46-3 ----
Tetrasodium salt of EDTA 64-02-8 ----
Sodium hydroxide 1310-73-2 X X X X
CERCLA/ SARA
Ingredient(s)CAS #Weight %CERCLA/SARA RQ (lbs)Section 302 TPQ (lbs)Section 313
Sodium hydroxide 1310-73-2 1% - < 3%1000
SARA 311/312 Hazard Categories
Immediate:x
Delayed:-
Fire:-
Reactivity:-
Sudden Release of Pressure:-
Canadian Regulations
16. OTHER INFORMATION
NFPA (National Fire Protection Association)
Rating Scale: (Low Hazard) 0 - 4 (Extreme Hazard)
Health 3
Flammability 0
Instability 0
Version Number: 1
Preparation date: 2014-05-01
Reason for revision:Not applicable
Prepared by:NAPRAC
Additional advice:
J-Works Tempest 64 Solvent-Free Cleaner/Detergent 5 of 5
• Does not contain an added fragrance
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.